Kinetics of magnetite oxidation under non-isothermal conditions

Aref Sardari; Eskandar Keshavarz Alamdari; Mohammad Noaparast; Sied Ziaedin Shafaei

doi:10.1007/s12613-017-1429-y

Volume 24 Issue 5

May 2017

Turn off MathJax

Article Contents

Article Navigation > International Journal of Minerals, Metallurgy and Materials > 2017 > 24(5): 486-492

Aref Sardari, Eskandar Keshavarz Alamdari, Mohammad Noaparast, and Sied Ziaedin Shafaei, Kinetics of magnetite oxidation under non-isothermal conditions, Int. J. Miner. Metall. Mater., 24(2017), No. 5, pp. 486-492. https://doi.org/10.1007/s12613-017-1429-y

Cite this article as:

Aref Sardari, Eskandar Keshavarz Alamdari, Mohammad Noaparast, and Sied Ziaedin Shafaei, Kinetics of magnetite oxidation under non-isothermal conditions, Int. J. Miner. Metall. Mater., 24(2017), No. 5, pp. 486-492. https://doi.org/10.1007/s12613-017-1429-y

Citation:

PDF( 1165 KB)

Research Article

Kinetics of magnetite oxidation under non-isothermal conditions

+ Author Affiliations

Corresponding author:
Eskandar Keshavarz Alamdari E-mail: alamdari@aut.ac.ir
Received: 10 May 2016; Revised: 6 November 2016; Accepted: 10 November 2016

Abstract

Abstract

Oxidation of magnetite concentrates, which occurs during the pellet induration process, must be deeply understood to enable the appropriate design of induration machines. In the present paper, the kinetics of the magnetite oxidation reaction was studied. Primary samples were obtained from the Gol-e-Gohar iron ore deposit. Magnetic separation and flotation decreased the sulfur content in the samples to be approximately 0.1wt%. Thermogravimetric analysis was used to measure mass changes during the oxidation of magnetite and, consequently, the conversion values. The aim of this study was to use isoconversional methods to calculate the kinetic parameters. The Coats-Redfern method was also used to obtain the activation energy. Thermogravimetric analyses were run at three different heating rates. The Coats-Redfern results were too ambiguous for a meaningful interpretation. In the case of the isoconversional method, however, the mean activation energy and pre-exponential factor of the oxidation reaction were obtained as 67.55 kJ and 15.32×10⁸ min^-1, respectively. Such a large activation energy implies that temperature strongly affects the reaction rate. The oxidation reaction exhibits a true multi-step nature that is predominantly controlled by chemical reaction and diffusion mechanisms.
- magnetite;
- kinetics;
- oxidation;
- thermogravimetric analysis

FullText(HTML)

Supplements(0)

References(23)

References

[1]	M. Barati, Dynamic simulation of pellet induration in straight-grate system, Int. J. Miner. Process., 89(2008), No. 1-4, p. 30.
[2]	T. Jiang, Y.B. Zhang, Z.C. Huang, G.H. Li, and X.H. Fan, Preheating and roasting characteristics of hematite-magnetite (H-M) concentrate pellets, Ironmaking Steelmaking, 35(2008), No. 1, p. 21.
[3]	K. Meyer, Pelletizing of Iron Ores, Vol. 1, Springer-Verlog, Berlin, 1980.
[4]	B.P. Yurev and N.A. Spirin, Oxidation of iron-ore pellets, Steel Transl., 41(2011), p. 400.
[5]	S.P.E. Forsmo, S.E. Forsmo, P.O. Samskog, and B.M.T. Björkman, Mechanisms in oxidation and sintering of magnetite iron ore green pellets, Powder Technol., 183(2008), No. 2, p. 247.
[6]	R. Liang, S. Yang, F.S. Yan, and J.C. He, Kinetics of oxidation reaction for magnetite pellets, J. Iron Steel Res. Int., 20(2013), No. 9, p. 16.
[7]	E.R. Monazam, R.W. Breault, and R. Siriwardane, Kinetics of magnetite (Fe₃O₄) oxidation to hematite (Fe₂O₃) in air for chemical looping combustion, Ind. Eng. Chem. Res., 53(2014), No. 34, p. 13320.
[8]	S. Vyazovkin and C.A. Wight, Isothermal and non-isothermal kinetics of thermally activated reactions of solids, Int. Rev. Phys. Chem., 17(1998), No. 3, p. 407.
[9]	S. Vyazovkin, K. Chrissafis, M.L.D. Lorenzo, N. Koga, M. Pijolat, B. Roduitf, N. Sbirrazzuoli, and J.J. Suñol, ICTAC Kinetics Committee recommendations for collecting experimental thermal analysis data for kinetic computations, Thermochim. Acta, 590(2014), p. 1.
[10]	S.P.E. Forsmo, Influence of Green Pellet Properties on Pelletizing of Magnetite Iron Ore[Dissertation], Lulea University of Technology, Lulea, 2007, p. 37.
[11]	A.W. Coats and J.P. Redfern, Kinetic parameters from thermogravimetric data, Nature, 201(1964), No. 4914, p. 68.
[12]	J.A. Conesa, A. Marcilla, J.A. Caballero, and R. Font, Comments on the validity and utility of the different methods for kinetic analysis of thermogravimetric data, Pyrolysis J. Anal. Appl. Pyrol., 58-59(2001), p. 617.
[13]	S. Vyazovkin, Isoconversional Kinetics of Thermally Stimulated Processes, Springer International Publishing, Switzerland, 2015.
[14]	T. Kujirai and T. Akahira, Effect of temperature on the deterioration of fibrous insulating materials, Sci. Pap. Inst. Phys. Chem. Res., 2(1925), p. 223.
[15]	T. Ozawa, A new method of analyzing thermogravimetric data, Bull. Chem. Soc. Jpn., 38(1965), No. 11, p. 1881.
[16]	J.H. Flynn and L.A. Wall, A quick, direct method for the determination of activation energy from thermogravimetric data, J. Polym. Sci. Part C, 4(1966), No. 5, p. 323.
[17]	ASTM, E1641:Standard Test Method for Decomposition Kinetics by Thermogravimetry, ASTM International, West Conshohocken, PA, 2004.
[18]	S.V. Vyazovkin and A.I. Lesnikovich, Estimation of the pre-exponential factor in the isoconversional calculation of effective kinetic parameters, Thermochim. Acta, 128(1988), p. 297.
[19]	S. Vyazovkin, A.K. Burnham, J.M. Criado, L.A. Pérez-Maqueda, C. Popescu, and N. Sbirrazzuoli, ICTAC Kinetics Committee recommendations for performing kinetic computations on thermal analysis data, Thermochim. Acta, 520(2011), No. 1-2, p. 1.
[20]	J. Hillier, T. Bezzant, and T.H. Fletcher, Improved method for the determination of kinetic parameters from non-isothermal thermogravimetric analysis (TGA) data, Energy Fuels, 24(2010), No. 5, p. 2841.
[21]	R. Ebrahimi-Kahrizsangi and M.H. Abbasi, Evaluation of reliability of Coats-Redfern method for kinetic analysis of non-isothermal TGA, Trans. Nonferrous Met. Soc. China, 18(2008), No. 1, p. 217.
[22]	M.E. Brown, M. Maciejewskib, S. Vyazovkinc, R. Nomend, J. Sempered, A. Burnhame, et al., Computational aspects of kinetic analysis:Part A. The ICTAC kinetics project-data, methods and results, Thermochim. Acta, 355(2000), No. 1-2, p. 125.
[23]	J.E. House, Principles of Chemical Kinetics, 2nd Ed., Vol. 1, Academic Press, Burlington, 2007.