Influence of solution concentration and temperature on the dissolution process and the internal structure of glauberite

Yan-mei Yu; Wei-guo Liang; Ji-shan Liu

doi:10.1007/s12613-018-1677-5

Volume 25 Issue 11

Nov. 2018

Turn off MathJax

Article Contents

Article Navigation > International Journal of Minerals, Metallurgy and Materials > 2018 > 25(11): 1246-1255

Yan-mei Yu, Wei-guo Liang, and Ji-shan Liu, Influence of solution concentration and temperature on the dissolution process and the internal structure of glauberite, Int. J. Miner. Metall. Mater., 25(2018), No. 11, pp. 1246-1255. https://doi.org/10.1007/s12613-018-1677-5

Cite this article as:

Yan-mei Yu, Wei-guo Liang, and Ji-shan Liu, Influence of solution concentration and temperature on the dissolution process and the internal structure of glauberite, Int. J. Miner. Metall. Mater., 25(2018), No. 11, pp. 1246-1255. https://doi.org/10.1007/s12613-018-1677-5

Citation:

PDF( 3322 KB)

Research Article

Influence of solution concentration and temperature on the dissolution process and the internal structure of glauberite

+ Author Affiliations

Corresponding author:
Yan-mei Yu E-mail: yym2009@126.com
Received: 29 March 2018; Revised: 13 May 2018; Accepted: 11 June 2018

Abstract

Abstract

Although transport in porous media under the influence of chemistry and temperature is a common phenomenon, the dissolution and internal structure evolution of glauberite during in-situ mining have been unique and challenging. This uniqueness indicates the complexity of mineral dissolutions, whereas the challenge represents the characterization of pore development and evolution during the dissolution processes. To investigate the microstructure development of glauberite under the influence of chemistry and temperature, experimental studies were performed with fine cuboid specimens of 4 mm×4 mm×9 mm soaked in solutions of different concentrations (fresh water, half-saturated, and saturated brine). The evolutions of internal structures were monitored through a micro computed tomography system. The statistical analysis indicated that the concentration and temperature of solutions significantly influenced the evolutions of pore size, porosity, and specific surface area of glauberite. The results showed that the increase in the rates of pore size, porosity, and specific surface area declined with time when glauberite was saturated in fresh water. The main reason for pore parameter variation is the differential concentration of solution. However, in the half-saturated and saturated solutions, the increase in rate increased with time. These observations suggest that the chloride ions contained in the saline solution could facilitate the dissolution of glauberite, whereas the existence of salt effect could contribute to the dissolution of calcium sulfate. Compared with the results at 20℃ and 65℃, the studied parameters of glauberite have dramatically decreased when the mineral was soaked in the solutions at high temperature (95℃). This function was most striking in fresh water. The dissolution of glauberite soaked in fresh water or half-saturated brine solution was conditioned by the temperature and solution concentration. However, the dissolution of glauberite was less influenced by temperature at high concentrations. These findings may feature significant implication for the effective recovery of mineral resources by in-situ solution mining method.
- solution mining;
- porosity evolution;
- glauberite dissolution;
- pore characterization

FullText(HTML)

Supplements(0)

References(28)

References

[1]	A. López, R.L. Frost, Y.F. Xi, and R. Scholz, A vibrational spectroscopic study of the sulfate mineral glauberite, Spectrosc. Lett., 47(2014), No. 10, p. 740.
[2]	W. Liang, C. Yang, Y. Zhao, M.B. Dusseault, and J. Liu, Experimental investigation of mechanical properties of bedded salt rock, Int. J. Rock Mech. Min. Sci., 44(2007), No. 3, p. 400.
[3]	A. Guinea, E. Playà, L. Rivero, and J.M. Salvany, Geoelectrical prospecting of glauberite deposits in the Ebro basin (Spain), Eng. Geol., 174(2014), p. 73.
[4]	E.C. Chan and F.S. Lien, Permeability effects of turbulent flow through a porous insert in a backward-facing-step channel, Transp. Porous Media, 59(2005), No. 1, p. 47.
[5]	Y.L. Yang and A.C. Aplin, Permeability and petrophysical properties of 30 natural mudstones, J. Geophys. Res., 112(2007), art. No. B3206.
[6]	K.F. Evans, Permeability creation and damage due to massive fluid injections into granite at 3.5 km at Soultz:2. Critical stress and fracture strength, J. Geophys. Res., 110(2005), art. No. B04204.
[7]	W.F. Brace, J.B. Walsh, and W.J. Frangos, Permeability of granite under high pressure, J. Geophys. Res., 73(1968), No. 6, p. 2225.
[8]	J.P. Greenberg and N. Møller, The prediction of mineral solubilities in natural waters:A chemical equilibrium model for the Na-K-Ca-Cl-SO₄-H₂O system to high concentration from 0 to 250℃, Geochim. Cosmochim. Acta, 53(1989), No. 10, p. 2503.
[9]	D. Freyer and W. Voigt, The measurement of sulfate mineral solubilities in the Na-K-Ca-Cl-SO₄-H₂O system at temperatures of 100, 150 and 200℃, Geochim. Cosmochim. Acta, 68(2004), No. 2, p. 307.
[10]	J.D. Toner and D.C. Catling, A low-temperature aqueous thermodynamic model for the Na-K-Ca-Mg-Cl-SO₄ system incorporating new experimental heat capacities in Na₂SO₄, K₂SO₄, and MgSO₄ solutions, J. Chem. Eng. Data, 62(2017), No. 10, p. 3151.
[11]	S.G. Xu, W.G. Liang, and Y.S. Zhao, Experimental study on dissolution characteristic of glauberite rock salt, J. Liaoning Technol. Univ., 24(2005), No. 1, p. 5.
[12]	X. Yang, X.R. Liu, W.J. Zang, Z.Y. Lin, and Q.Y. Wang, A study of analytical solution for the special dissolution rate model of rock salt, Adv. Mater. Sci. Eng., 2017(2017), p. 1.
[13]	D.N. Dewhurst, A.C. Aplin, and J.P. Sarda, Influence of clay fraction on pore-scale properties and hydraulic conductivity of experimentally compacted mudstones, J. Geophys. Res., 104(1999), No. B12, p. 29261.
[14]	D. Yang, Y.S. Zhao, and Y.Q. Hu, The constitute law of gas seepage in rock fractures undergoing three-dimensional stress, Transp. Porous Media, 63(2006), No. 3, p. 463.
[15]	Y.S Zhao, F. Qu, Z.J. Wan, Y. Zhang, W.G. Liang, and Q.R. Meng, Experimental investigation on correlation between permeability variation and pore structure during coal pyrolysis, Transp. Porous Media 82(2010), No. 2, p. 401.
[16]	W.G. Liang, Y.S. Zhao, S.G. Xu, and M.B. Dusseault, Dissolution and seepage coupling effect on transport and mechanical properties of glauberite salt rock, Transp. Porous Media, 74(2008), No. 2, p. 185.
[17]	Z.H. Liu, Y.Q. Hu, S.G. Xu, W.G. Liang, D. Yang, and Y.L. Zhao, Experimental study of pore evolution law during dissolution-recrystallization for glauberite, Chin. J. Rock Mech. Eng., 30(2011), Supp. 1, p. 2743.
[18]	P. Trinchero, J. Molinero, G. Deissmann, U. Svensson, B. Gylling, H. Ebrahimi, G. Hammond, D. Bosbach, and I. Puigdomenech, Implications of grain-scale mineralogical heterogeneity for radionuclide transport in fractured media, Transp. Porous Media, 116(2017), No. 1, p. 73.
[19]	Q.H. Hu, T.J. Kneafsey, J.J. Roberts, L. Tomutsa, and J.S. Wang, Characterizing unsaturated diffusion in porous tuff gravel, Vadose Zone J., 3(2004), p. 1425.
[20]	H.H. Liu, C.B. Haukwa, C.F. Ahlers, G.S. Bodvarsson, A.L. Flint, and W.B. Guertal, Modeling flow and transport in unsaturated fractured rocks:An evaluation of the continuum approach, J. Contam. Hydrol., 62-63(2003), p. 173.
[21]	H.H. Liu, R. Salve, J.S. Wang, G.S. Bodvarsson, and D. Hudson, Field investigation into unsaturated flow and transport in a fault:Model analysis, J. Contam. Hydrol., 74(2004), No. 1-4, p. 39
[22]	M. Pyrgioti, A. Kyriakidis, S. Chrysostomou, and V. Panaritis, Using digital photo technology to improve visualization of gastric lumen CT images, Nucl. Instrum. Methods Phys. Res. Sect. A, 569(2006), p. 614.
[23]	R. Forghani and S.K. Mukherji, Advanced dual-energy CT applications for the evaluation of the soft tissues of the neck, Clin. Radiol., 73(2018), No. 1, p. 70.
[24]	P. Dawson, Functional imaging in CT, Eur. J. Radiol., 60(2006), No. 3, p. 331.
[25]	L. Yu and D.W. Qi, Analysis and processing of decayed log CT image based on multifractal theory, Comput. Electron Agric., 63(2008), No. 2, p. 147.
[26]	J.B. Sun and J.K. Liu, The mechanism of salt expansion in saline soil, Subgrade Eng., 2007, No. 1, p. 44.
[27]	G. Schena and S. Favretto, Pore space network characterization with sub-voxel definition, Transp. Porous Media, 70(2007), No. 2, p. 181.
[28]	Y.M. Yu, W.G. Liang, Y.Q. Hu, and Q.R. Meng, Study of micro-pores development in lean coal with temperature, Int. J. Rock Mech. Min. Sci., 51(2012), p. 91.