Hong-liang Xiang, Yu-rui Hu, Hua-tang Cao, Dong Liu, and Xuan-pu Dong, Erosion-corrosion behavior of SAF3207 hyper-duplex stainless steel, Int. J. Miner. Metall. Mater., 26(2019), No. 11, pp. 1415-1426. https://doi.org/10.1007/s12613-019-1825-6
Cite this article as:
Hong-liang Xiang, Yu-rui Hu, Hua-tang Cao, Dong Liu, and Xuan-pu Dong, Erosion-corrosion behavior of SAF3207 hyper-duplex stainless steel, Int. J. Miner. Metall. Mater., 26(2019), No. 11, pp. 1415-1426. https://doi.org/10.1007/s12613-019-1825-6
Research Article

Erosion-corrosion behavior of SAF3207 hyper-duplex stainless steel

+ Author Affiliations
  • Corresponding authors:

    Hong-liang Xiang    E-mail: hlxiang@fzu.edu.cn

    Hua-tang Cao    E-mail: chtpmd@163.com

  • Received: 16 May 2019Revised: 28 July 2019Accepted: 31 July 2019
  • Polarization curves and mass losses of SAF3207 hyper-duplex stainless steel under various conditions were measured. The damaged surfaces after erosion-corrosion tests were characterized by scanning electron microscopy. The results showed that an increase in flow velocity could enhance the electrochemical corrosion and consequently decrease the passivation properties of the steel. The erosion-corrosion damage of the samples increased substantially when the flow velocity exceeded the critical value of 4 m·s-1. The mass loss rate increased as the sand content increased, reaching a maximum at 7wt% sand content, corresponding to the most severe electrochemical corrosion damage. When the sand content was increased further, however, the mass loss rate decreased and then tended stable. The mass loss was divided into incubation, sustained, and stationary periods, with a maximum mass loss rate of 12.97 g·h-1·m-2 after an erosion period of 2.5 h. The erosion-corrosion mechanism was investigated in detail.
  • loading
  • [1]
    A.M. Rashidi, M. Packnezhad, M. Moshrefi-Torbati, and F.C. Walsh, Erosion-corrosion synergism in an alumina/sea water nanofluid, Microfluid. Nanofluid., 17(2014), No. 1, p. 225.
    [2]
    M.A.L. Hernández-Rodríguez, D. Martínez-Delgado, R. González, A. Pérez Unzueta, R.D. Mercado-Solís, and J. Rodríguez, Corrosive wear failure analysis in a natural gas pipeline, Wear, 263(2007), No. 1-6, p. 567.
    [3]
    H. Meng, X. Hu, and A. Neville, A systematic erosion-corrosion study of two stainless steels in marine conditions via experimental design, Wear, 263(2007), No. 1-6, p. 355.
    [4]
    L. Wei, Q.H. Zhao, and S.Z. Li, Relationship between the specific surface area of rust and the electrochemical behavior of rusted steel in a wet-dry acid corrosion environment, Int. J. Miner. Metall. Mater., 24(2017), No. 1, p. 55.
    [5]
    M.A. Islam and Z.N. Farhat, The synergistic effect between erosion and corrosion of API pipeline in CO2 and saline medium, Tribol. Int., 68(2013), p. 26.
    [6]
    J.J. Shi and J. Ming, Influence of mill scale and rust layer on the corrosion resistance of low-alloy steel in simulated concrete pore solution, Int. J. Miner. Metall. Mater., 24(2017), No. 1, p. 64.
    [7]
    J. Zhu, Q.B. Zhang, Y. Chen, Z. Zhang, J.Q. Zhang, and C.N. Cao, Progress of study on erosion-corrosion, J. Chin. Soc. Corros. Prot., 34(2014), No. 3, p. 199.
    [8]
    I. Weibull, Duplex stainless steels and their application, particularly in centrifugal separators. Part A, History & Development, Mater. Des., 8(1987), No. 1, p. 35.
    [9]
    X. Gu, H.L. Xiang, Q.M. Lu, and Y.X. Wang, Effect of solution temperature on the microstructure and corrosion resistant of hyper duplex stainless steel, Spec. Cast. Nonferrous Alloys, 33(2013), No. 10, p. 899.
    [10]
    F.S. He, H.L. Xiang, X. Gu, and D. Lu, Cavitation erosion behavior of Cr32Ni7Mo3N super duplex stainless steel, J. Univ. Sci. Technol. Beijing, 36(2014), No. 8, p. 1060.
    [11]
    H.C. Tian, X.Q. Cheng, Y. Wang, C.F. Dong, and X.G. Li, Effect of Mo on interaction between α/γ phases of duplex stainless steel, Electrochim. Acta, 267(2018), p. 255.
    [12]
    B.M. Wei, Corrosion Theory and Application of Metals, Chemical Industry Press, Beijing, 1984, p. 55.
    [13]
    Y.L. Cheng, Study of the Electrochemical Properties of the Corrosion of Aluminum Alloys in Neutral Sodium and Thin Electrolyte Layers[Dissertation], Zhejiang University, Zhejiang, 2003, p. 69.
    [14]
    H.L. Xiang, J.C. Fan, D. Liu, and X. Gu, Effects of antibacterial aging treatment on microstructure and properties of copper-containing duplex stainless steel II. Corrosion resistance and antibacterial properties, Acta. Metal. Sin., 48(2012), No. 9, p. 1089.
    [15]
    J.T. Huang, Theory and Application of Cavitation and Cavitation Erosion, Tsinghua University Press, Beijing, 1991, p. 113.
    [16]
    E.A.M. Hussain and M.J. Robinson, Erosion-corrosion of 2205 duplex stainless steel in flowing seawater containing sand particles, Corros. Sci., 49(2007), No. 4, p. 1737.
    [17]
    Y.G. Zheng, Z.M. Yao, K. Long, S.C. Li, and W. Ke, The development of liquid/solid two phase flow erosion experiment device and dynamic electrochemical test, Corros. Sci. Prot. Tech., 5(1993), No. 4, p. 286.
    [18]
    X.Y. Yong, Y.Z. Lin, J.J. Liu, and S.J. Liu, Erosion corrosion of duplex stainless steel in flowing neutral chloride containing sand, Acta. Metall. Sin., 37(2001), No. 7, p. 745.
    [19]
    X.X. Jiang, S.Z. Li, S. Li, Corrosive Wear of Metals, Chemical Industry Press, Beijing, 2002, p. 113.
    [20]
    M. Papini, D. Ciampini, T. Krajac, and J.K. Spelt, Computer modelling of interference effects in erosion testing:Effect of plume shape, Wear, 255(2003), No. 1-6, p. 85.
    [21]
    A. Neville, F. Reza, S. Chiovelli, and T. Revega, Erosion-corrosion behaviour of WC-based MMCs in liquid-solid slurries, Wear, 259(2005), No. 1-6, p. 181.
    [22]
    Y.G. Zheng, H. Yu, S.L. Jian, and Z.M. Yao, Effect of the sea mud on erosion-corrosion behaviors of carbon steel and low alloy steel in 2.4% NaCl solution, Wear, 264(2008), No. 11-12, p. 1051.
    [23]
    J.S. Sun, Wear of Metals, Metallurgical Industry Press, Beijing, 1992, p. 450.
    [24]
    W. Liu, Y.G. Zheng, Z.M. Yao, X.Q. Wu, and W. Ke, Cavitation erosion of 20SiMn and 0Cr13Ni5Mo steels in distilled water with and without sand, Acta. Metall. Sin., 37(2001), No. 2, p. 197.
    [25]
    Z.B. Zheng, Y.G. Zheng, W.H. Sun, and J.Q. Wang, Erosion-corrosion of HVOF-sprayed Fe-based amorphous metallic coating under impingement by a sand-containing NaCl solution, Corros. Sci., 76(2013), p. 337.
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索

    Share Article

    Article Metrics

    Article Views(562) PDF Downloads(14) Cited by()
    Proportional views

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return